NI 9264现货 in stock! 欢迎来电咨询~！！

NI 9264,

NI 9264

有福之州-福州聚福兴供应进口工业控制系统成套备件：DCS PLC模块卡件，底板机架机槽，CPU模块，输入输出模块，模拟量模块，电源模块，通讯模块，工业交换机，触摸屏人机界面显示器，插头连接器，连接电缆接插电缆，伺服控制器，电机马达，伺服驱动器，驱动板电源板电路板，采集卡，影像卡，工控机，示教器，工业机器人配件..........
有福之州-福州聚福兴供应自动化供应进口品牌：罗克韦尔AB， Prosoft，西门子SIEMENS，施耐德SCHNEIDER，通用电气GE FANUC， 发那科FANUC，安川Yaskawa，欧姆龙Omron，三菱Mitsubishi，基恩士Keyence，东方步进Vexta，迈创Matrox，美家仪器NI，研华Advantech，莫迪康Modicon，思科Cisco，大隈Okuma，瑞士ABB，力士乐 Bosch Rexroth，台达Delta，福克斯波罗Foxboro，富士Fuji，霍尼韦尔Honeywell，惠普Hp，瑞恩 Reliance...........

欢迎咨询~~~~~

　　1 引言

　　纺丝机纺出的涤纶原丝需经过牵伸定型后,才具有一定的纤度、强度、伸度和其它的物理性能。VC443A牵伸加捻机用于涤纶复丝生产过程中牵伸加捻工序。牵伸丝为低捻复丝，可直接或经加弹工序后供绸厂使用。它的电气部分由电源控制系统、程序控制系统、锭子交流变频调速系统、热盘控制系统、热板控制系统组成。随着机电一体化技术的发展，对系统的可靠性要求愈来愈高，因PLC具有控制可靠、体积小、功能强、速度快,组态灵活和可扩展性的特点而得到了广泛的应用，成为自动化系统中的基本电控装置，故VC443A牵伸加捻机选用PLC可编程控制器，实现了生产的自动控制。

　　2 PLC选型设计

　　系统选用了日立公司的产品:E-64HR可编程控制器,作为主控单元，它有64个输入/输出点,其中40个开关量输入点，24个输出点，内置式电擦除EEPROM可以保护用户方便的完成程序和参数的修改和存储, PLC根据各输入点所接按钮，接近开关，接触器等电器信号的状态以及编制的软件程序自动控制各电机，电磁阀，指示灯等，完成整个生产的工艺动作程序，钢领板换向及成型自动控制。E-64HR具有多种编程工具:通用编程器PGMJ-R和标准编程器PGNJ等，体积小携带方便，可在现场实地进行程序调整和传送。全部控制程序约276条，可见该系统软硬件资源得到了相当充分的利用。

　　3 VC443A牵伸加捻机工艺

　　3.1 输入信号

　　VC443A牵伸加捻机控制系统的输入信号:主令按钮、限位开关、接近开关、钮子开关、拨盘开关的投入信号，全部为直流输入，共有40点。

　　3.2 输出信号

　　控制的负载主要分成三类:一是7台交流电机:牵伸双速电机M1、油泵电机M2、靠模升电机M3、靠模降电机M4、移丝电机M5、锭子电机M6、风机M7;二是用于控制钢领板升降及侧压辊压差的电磁阀;三是信号灯;四是计数器，共有24点，全部为继电器接点输出信号。

　　3.3 开车主要控制过程

　　(1) 按“油泵开”按钮SB7，使接触器KM5吸合， 油泵开指示灯亮, 油泵电机M2运转。(程序器的输出50对应的LED发光)。

　　(2) 按“低速开”按钮SB9。

　　●辅助接触器KA1吸合，锭子低速运转。(程序器的输出51对应的LED发光)

　　●程序器控制下，使计数器复零，进入准备工作状态，内部定时器T01 T02接通，使钢领板强迫进入废丝盘位置，待TO0延时到断开快速阀YV3，钢领板在程序器控制下微动。(程序器的输出76、65对应的LED发光，延时到熄灭，66、67对应LED交替发光)

　　●定时器TO1延时到，使接触器KM3吸合，牵伸双速电机M1带动牵伸罗拉和上下牵丝盘低速运转，低速指示灯亮，进入挂丝阶段。(程序器的输出52对应的LED发光)

　　(3) 按“高速开”按钮SB11。

　　●辅助接触器KA2吸合，使锭子高速运转。(程序器的输出53对应的LED发光)

　　●程序器控制使电磁阀YV4断电，侧压辊加压。(程序器输出64对应LED发光)

　　●定时器T02接通，延时到后接触器KM4得电，牵伸双速电机M1切换为高速运转，高速指示灯亮，继电器KA3吸合，移丝电机M5运转。(程序器输出54对应的LED发光。55对应的LED发光)

　　●定时器T03延时到后，钢领板强迫上升，靠模上撞块使底部打结开关SA2接通，定时器T04得电，使上升阀失电，实现底部打结，T04延时到上升阀YV1/1再次得电，强迫钢领板快速上升，进入正常牵捻区，待T05延时到后切断快速阀YV3，钢领板在程序器控制下，以正常速度运动，同时接通继电器KA4，靠模升电机M3运转，带动靠模缓慢上升，计数器开计长(程序器56对应的LED发光。65对应的LED在接通快速阀时发光，74对应的LED发光，有计长信号时发光指示)。

　　至此开车过程结束，机器进入正常纺丝。
 

150-C43NCR SMC-3 43A Smart Motor Controller

1585D-M4HBDM-40 Micro D-Code, QD Style Ethernet Media

1746-A7 SLC 7 Slots Chassis

1769-OB32 CompactLogix 32 Pt 24VDC D/O Module

193-T1AC16 11.3-16 A IEC Bimetallic Overload Relay

194R-R4 Operating Shaft

2090-CSBM1DF-18AF07 Kinetix Cable Single DSL 2090-Series

2097-R7 Kinetix 300/350 150 Ohm Shunt Resistor

BC646MVSU02 View Standard Edition Upgrade from View for QuickPanel View Standard Edition with Proficy GlobalCare Complete

GC647AUR025 GC Universal Reporting Client 25 pak

IC200ACC414 The ACC414 is a long term battery for the VersaMax Micro 20, 23, 28, 40 and 64 point CPUs. The battery will backup upto 7 years.

IC646CSPR010 Proficy Cause+ for Intelligent HMI/SCADA Runtime Server - 10X monitored KPIs

IC647IFPLSR00075M iFIX Plus SCADA 75 I/O Server (M4 Part)

IC660MLA105 Label for IC660BBA105 (Qty 100)

IC697ALG444 Analog Input Expander, Current, 16 Channels gold plated terminal. WARNING: The IC697ALG444 module must be matched with IC697ACC775 terminal block ONLY. IC697ACC775 is included with the module.

IC760STA100 StationPortal. Stand-alone I/O device supporting Ethernet. Includes universal power supply.

FlexLogix System 1794-STRT1DE FLEXLOGIX STARTER KIT GERMAN

GuardPLC Systems 1753-PCSUSB RSLOGIX GUARD PLUS FOR GUARDPLC - USB HARDLOCK

Process Control 1757-UPGSIFZA UPGRADE APPLICON QUICKBUILDER I/F

Operator Interface 2711P-T12C6D2 PV PLUS 1250, TOUCH, RIO/DH, DC PS, EXT MEM

Support 9220-WINTAR SUPT REINSTATEMENT CONTRACT FOR 9220WINTA

Support 2755-LHS1S SUPT RENEWAL CONTRACT FOR 2755LHS1

Support F1785-V40BSERC FIRMWARE UPGRADE FOR 1785-V40B PLC5 PROCESSOR MODU

RSI Software Products 9301-2SE2350KOU2 RSVIEW32 WORKS 300-5K UPGRADE IN-SUPT (KO)

RSI Software Products 9701-VWSTMENE RSVIEW STUDIO FOR MACHINE EDITION

RSI Software Products 9399-WABOUGDE RSLINX OEM USERS GUIDE (GERMAN)

Motion Control 8720MC -D180-AN- 180 AMP D CHASSIS DRIVE, OPEN ENCL., LESS OPTIONS

BC646MRC000 Logic PC & View Runtime 8,000 I/O

IC300PDA001 OCS Handheld Programmer

IC754CKL12CTD Starter Kit, 12 TFT Ctrl Loaded, 24VDC"

MTR-3T45-I-R-B-M-0RR Servo Motor Metric 24V Brake

PCI-6713

STM-5 R1.5

PCA-6186E2

Allied Telesyn安奈特 AT-2711FX/LC

ARBOR EmCORE-i6419

PIO-16/16B(PCI)

1492-LD4RB822 Terminal Block, Resistor, 8.25K Ohms

1494F-LL4 Door Hardware Kit

软启动器 3RW44352BC46

ET 200SP 6ES7193-6AP40-0AA0 BA 1×SCRJ光纤/1×FC 快连式

1585D-E4TBDE-0M3 Micro D-Code, QD Style Ethernet Media

1751-SLBA SynchLink Fiber Base Block

1794-IB10XOB6 Flex 10 Input 6 Output Digital Module

194E-AA20E-P11-TN 194E Load switch

2080-LC20-20AWB Micro820 20 I/O ENet/IP Controller

2090-CSWM1DF-14AA19 Kinetix Cable Single DSL 2090-Series

20AC2P1F0AYNANC0 PowerFlex 70 AC Drive 20A

GC646MPP010 Proficy GlobalCare Complete for Logic Developer - PLC Professional - 10 Pack

HE693OIU297 Compact VF Genius w/4-line display, powered by 24VDC

IC610CCM105RR Series One Plus Data Communications Unit (DCU)

IC647HSTSC2000KM Server to Server Collector for Historian - Standard Server 2,000,000 Points (M4 Key)

IC660BBA101RR RTD Input Block, 115Vac/125Vdc Power, 6 Chans, Ph B

IC694MDL752CA Conformal Coated Output module, 5/12-24VDC, 32 point NEG logic.

IC756WDJ009E-99 DV Development Sys VB and Java, English, Version 9.9

MicroLogix 1500/1769 System 9399-RL50GRES RSLOGIX 500 GETTING RESULTS GUIDE (SPANISH)

PLC-5/1771 System 1771-CP2 1771 I/O CHASSIS CABLE FOR 1771-P7 POWER SUPPLY

Distributed I/O 1797-PS1E 85-250 VAC IN QUAD-EX IS OUT POWER SUPPLY-IS TERM.

Operator Interface 2711P-B6C3A PV PLUS 600 COLOR, KEY/TOUCH, DH485, AC PS

Support 9323-PA1IS SUPT RENEWAL CONTRACT FOR 9323PA1I

Support 9358-HSTSSROLR SUPT REINSTATEMENT CONTRACT FOR 9358HSTSSROL

Support F1772-LXPSERC FIRMWARE UPGRADE FOR 1772-LXP PLC2 PROCESSOR MODUL

RSI Software Products 9324-RLD3U7ITE RSLOGIX 5000 STD. TO PRO UPGRADE, ITALIAN

RSI Software Products 9305-RSVADDCFRE RSVIEW32 ACTIVE DISPLAY DED. CLIENT (FRENCH)

RSI Software Products 9358-RTI10E RTI DATA COLLECTOR 10 CONFIGURATION

Motion Control 2092-DA5 DRIVE, 16.4A/43.4A, ULTRA1500 DIGITAL SERVO DRIVE

A06B-0143-B075#7076 A12/3000 Servo Motor, IP67 Sealing, 64K Serial Encoder

IC200UDD110-24 Qty of 24, 28 point PLC, (16) 24VDC In, (12) 24VDC Out (6) 1.0A, (6) 0.5A, 24VDC Power Supply. Battery (IC200ACC403) is required for data retention.

IC752BUU024 VT100 Upgrade for Datapanel J+

MTR-1454-N-A-E-SRR Stepping Motor Nema42 Splashproof

NI 9221

MBA-9454G-R10

NPE-1G-2GE

Wincor 1750181455

IPC-610G SIMB-A01/E5300/4G/500G

ASM 03-20909

NuPRO-770/771

1492-SPM3C500 MCB Supplementary Protector 50 A

软启动器 3RW40461TB05

模拟量输出信号板 6ES7 232-4HA30-0XB0 SB 1232 AQ 1x12 位

150-SC3NBD SMC-50 SOLID STATE MOTOR CONTROLLER 320A

1734-VHSC5 POINT I/O Very High Speed Counter Module

1783-SRKIT Stratix 5900 Services Router Kit

193-ESM-VIG-60A-C55 E300/E200 60 Amp Sensing Module

20-750-IP20GI-F2 PF753 & PF755 FR 2 EMC CORES W PLATE

2090-CPWM7DF-16AA25 MP-Series 25m Servo Power Cable

20A-DG01 PowerFlex 70 DriveGuard Board Kit

GA647IFESGDV00300 GCA iFIX Optn: ESig & ERec 300 I/O Dev

GP-2104NT GagePort Digital NT 4-port input

IC5007TBX0030 PanelPC 17 inch Performance Unit Deluxe with Windows XP

IC647HSTCC100M Calculation Collector for Historian - Standard Server 100 Points (M4 Key)

IC647SVB001 Scheduler Visma Business Adapter

IC693MDL750RR 12/24 Vdc Output, Negative Logic (32 Points)

IC756LDV000E64-925 DataViews Development on Intel Linux/Red Hat 64 bit Op Sys, English v9.25

Pico Controllers 1760-IB12XOW4IF 12 DC IN 4 RELAY OUT AI

PLC-5/1771 System 1771-OBDS CURRENT LIMITING OUTPUT MODULE, 10-20V DC

Distributed I/O 1791R-0B16P RIO 24VDC COMPACTBLOCK, 16 OUT SOURCE, BASE

Communications 1786-BNC2TNC CONTROLNET BNC-TNC COAXIAL CONN - ISOL BULKHEAD

Operator Interface 2706-PDNETK DEVICENET COMMUNICATION MODULE FOR 2706-P7X & P9X

Support 9701-VWSB100AR SUPT REINSTATEMENT CONTRACT FOR 9701VWSB100AENE

Support 1747-PBASES BASIC DEVELOPMENT SOFTWARE SLC500 FAMILY RENEWAL

EtherNet/IP Products 2711P-K10C4B2 PV PLUS 1000, KEYPAD, ENET, AC PS, EXT MEM

RSI Software Products 9301-2SE340JPU2R RSVIEW32 RUNTIME 300-32K UPGRADE OUT-SUPT (JP)

RSI Software Products 9356-PRO2350U2 UPGRADE: IN-SUPT: RSSQL STD.300 TO PROF.5000 TAG

Motion Control 1326AB-B740E-S2L MOTOR,SERVO,460V,50.0NM,3400RPM,SINGL,IP67

4261A-4-N12 7 SEG Panel DISP. 4 Digit. ASCII/Serial Interface. Quick CONN W/Protocol CONV. NEMA 12

HMI-KPN-403 QuickPanel Keypad for 12.1" QPLCxxx0000

IC693CPU374CA Series 90-30 CPU374 Conformal Coated.

TGT-000A-2-0 Target 2-Axis Motion Control Module

AKD-P02406-NBEC-0000

FSC-1815

OSCILLOQUARTZ 956.300.469-9

超微P3TDE6

TVGA8900D-R

KJ020800

ATIO-032575B

1492-SPM1D060 MCB Supplementary Protector 6 A

通用型变频器 6SE6 440-2UD15-5AA1 0.55KW,73 x 173 x 149

电机启动器 3VU13403ML00

150-C3FBD-8L Encl. SMC-3 0.125 Smart Motor Controller

1609-P5000E Uninterruptible Power Supply P UPS Acces

1771-CP2 1771-P7 Power Supply Cable

193-EC2BB E3 Plus 3-15 A Overload Relay

198-H4 MECHANISM CIRCUIT BREAKERFOR STARTER

2090-CPBM7E7-16AF02 MP-Series 2m Length Pwr and Brake Cable

2094-AC16-M03-S Kinetix 6000 Integrated Axis Module

CP9I-0MPB-0140-AZ Alpha 50HVis motor power cable (14 meter)

GFK-0398 Series 90-70 PLC Genius Bus Controller User's Manual

IC200UEX264 VersaMax Micro 64 point expansion (40) 24VDC inputs, 24VDC source outputs with ESCP, 24VDC power supply. Compatible with Micro 20/40/64 revision -Bx hardware only version 4.0 firmware and above.

IC647APC010 PA ProductionClient 10 Pak

IC647PDNC PDN:Koyo PLC Direct DL405

IC693CHS397 Base, CPU, 5 Slots, Use With CPU331/CSE331 and above

IC754DVNS01 DeviceNet Slave for QP View

KIT-GFS-357-CN Proficy HMI/SCADA CIMPLICTY WKSHP KIT

SLC/1746 System D1747-6.13 REMOTE I/O ADAPTER MODULE USER MANUAL

Distributed I/O 1734D-IA8XOA8S 120 VAC 8 IN 8 OUT, DNET COMMS, SPRING

Application-specific products 1803-CT1000M PORTABLE POWERMONITOR2 CURRENT XFMR 1K/500/250

Operator Interface 2711-T10C8 PV1000 COLOR TOUCH, DH+ & RS232 PRINT

Support 9301-2SE3500DES SUPT RENEWAL CONTRACT FOR 93012SE3500DE

Support 9381-PA250KENR SUPPORT REINSTATEMENT CONTRACT FOR 9381PA250KEN

DeviceNet Products 1790D-T0B16 DNET LDX, 24VDC, 16 SOURCE OUT BASE, TERMINAL BLK

RSI Software Products 9301-2SE3303ZHE RSVIEW32 RUNTIME 1500 WITH RSLINX (CHINESE)

RSI Software Products 9358-PBBK10ENE RSBIZWARE BATCH FOR PLX BACK-UP KEY 10 UNITS

Motion Control MPL-B560F-MJ24AA MOTOR,SERVO,26.8NM,3000RPM,MULTI,460V,BRK

Motion Control 2090-UXLF-123 AC LINE FILTER,ULTRA,23 AMPS,1 PHASE

GQPM3D200B2P 6" Blue Monochrome Mini, GE Fanuc Label, 24Vdc

IC646MSS005 Logic Developer - State Standard - 5 Pack

MTR-3T45-I-R-0-M-0 MTR-Series Servo Motor, Resolver, Metric

ST-1228 STXi input module 8 points, Negative Logic, 12V/ 24VDC

SCXI-1127

VS08/PCI

ASI4215 PCB4200

interface pci-2702c

PCL-839+

PCA-6175

1492-RCDA4A40 Residual Current Device 40 A

存储卡 6ES7952-1KS00-0AA0 FEPROM 存储卡， 16M

变送器 3RS10 40-2GD50

1497-G-BASX-3-N Control Circuit Transformer

1606-XLDNET4 1606 Power Supply

1762-OV32T MicroLogix 32 Point Module

188-K3D060-N 6 A Miniature Circuit Breaker

194L-HCB-001 194L Control and Load Switch Actuator

2090-CPBM7DF-06AA90 MP-Series 90 m Length Cable

2090-XXNPMF-14S02 MP-Series 2 m Length Pwr and Brake Cable

BC647TPR000 CIMPLICITY HMI ProServer No Limit Runtime System with Proficy GlobalCare

GC647PRTORA GlobalCare Complete - Proficy Portal Oracle Connector Ver 3.0

IC200MDL743 Output 5/12/24VDC NEG LOGIC 0.5A per point (1 group of 16) 16 points

IC646PHA772 PA-70H with 772 CPU - AC

IC647MSAC MSA:Mine Safety DAN

IC684TR000320 CIMPLICITY HMI Functionality Thru Scripting (Level 2) (3 Days)

IC697VAL134 Module discontinued. Replacement is VME-3125A-100000 different front panel connector. Contact GE IP Embedded for details.

IC800SSI228P2 28 amp 230 VAC Profibus S2K servo controller for S-series motors

SLC/1746 System 1747-L542 SLC 5/04 CONTROLLER, 32K MEMORY

Industrial Computers 6181P-12NPXPH VERSAVIEW INTEGRATED DISPLAY COMPUTER 12-INCH TFT

Application-specific products 9358-PBANT03ENE RSBATCH NT FOR PROCESSLOGIX ARCHIVER 03 UNITS

Operator Interface 2711-B5A9L3 PV550 MONO KEY&TOUCH, DH+ & RS232 PRINT

Support 9303-4DTS01ENR SUPT REINSTATEMENT CONTRACT FOR 93034DTS01ENE

Support 9393-RSCOMP500R SUPT REINSTATEMENT CONTRACT FOR 9393COMP500

ControlNet Products 2711-K6C15 PV600 COLOR KEY, CNET & RS232 PRINT

RSI Software Products 9301-2SE2500PTE RSVIEW32 WORKS 100K (PORTUGUESE)

RSI Software Products 9358-BEPB10ENE RSBIZWARE BATCH AND EPROCEDURE BUNDLE 10 UNITS

Motion Control MPL-A4540C-MJ24AA MOTOR,SERVO,10.2 NM,1500RPM,MULTI,230V,BRK,13KG

Motion Control 2090-XXNFMP-S30 CABLE,NON-FLEX,MOTOR FEEDBACK,MP/1326AB,30M

CBL-T7-MB-20 Power/Brake Cable, MTR-3T1x & MTR-3T2x Series Servo Motors, 20 Ft.

IC641PCC016 Toolkit, Function Block, C

IC800SSD107RS1 7.2A, 115/230V, S2K Servo Drive for MTR Series Motors

PR-PAT-BRK01 Proficy PAT - Driver For Bruker Ftir Spectrometers

PXI-6120

ATX6022-14G

MIC-3390

AX98690

PCA-6184E2

PEAK639VL2

1492-MR8X12H1-50 Connection Products

1495-N34 Electrical Interlock

行程开关 3SE53120SD11

运行版软件 6AV2105-0MA04-0AA0 SIMATIC WinCC Runtime 专业版 65536 PowerTags V14

1585J-M4TBJM-5 RJ45 Ethernet Media

1756-OF8 ControlLogix 8 Pt A/O I or V Module

188-K1C040 Miniature Circuit Breaker 4 A

194E-GA32E-P22 194E Load switch

2090-CFBM7DF-CEAA04 MP-Series 4m Servo Feedback Cable

2090-UXCK-D15 Ultra Series Breakout Board Kit

BC646PCN110 OP Operator Console Runtime S/W 700 I/O w/GC

GC647DMS010 GC DataMart 10 PA Connections

IC200ALG264 Analog input 15 bit current 15 channel

IC646IFCLNTCRO025K iFIX iClient Read Only 25 PK Keyless (M1 Kit Part)

IC647IFPRDV00075K iFIX Profsnl SCADA 75 I/O Development (M1 Kit Part)

IC660MLS101 Label for IC660BBS101 (Qty 100)

IC697BEM741RR FIP Bus Controller 9070

IC800BIHV010 BSVM1-10HVi Beta HVi 10 amp amplifier kit

ControlLogix/1756 System 1756-L55M23 LOGIX5555 PROCESSOR WITH 1.5MBYTE NV MEMORY

Industrial Computers 6182H-7BRH15B VVCE 700, KEY/TOUCH, STD MEM, CNET, AC

Process Control 9323-ATUNEENE LOOP TUNER FOR LOGIX5000 PIDE FUNCTION BLOCK

Operator Interface 2711P-K15C15B2 PV PLUS 1500, KEYPAD, CNET, AC PS, EXT MEM

Support 9240-WIN16SDKR SUPT REINSTATEMENT CONTRACT FOR 9240WIN16SDK

Support 6723-PCSS SUPPORT RENEWAL CONTRACT FOR 6723-PCS

Support F5130-RM2 FIRMWARE UPGRADE FOR 5130-RM2 PLC5250 PROCESSOR MO

RSI Software Products 9301-2SE2350ZHU2 RSVIEW32 WORKS 300-5K UPGRADE IN-SUPT (ZH)

RSI Software Products 9351-OSF INTERCHANGE FOR DIGIAL UNIX

RSI Software Products 9399-WINIG WINDOWS-BASED PRODUCTS INSTALLATION GUIDE

Motion Control 8720MC-VA-B 460VAC VARISTOR

BC646MRE075 Logic PC & View Runtime (HRT) 75 I/O

IC300RTD100 4 channel RTD Inputs (Pt-100, Pt-200, Pt-500, Pt-1000), 18 bit

IC754VKI10MTD Starter Kit - 10" Monochrome QuickPanel View Intermediate, Touch, 24VDC

MTR-3T57-H-R-0-M-0 MTR series metric servo motor with resolver

PCI-8431/2 (RS485/RS422)

PFM-535I

IPC-606P3(B)

M470-2 D2778-C14